2.3.3 CELLS AND BATTERIES FOR DISPOSAL AND RECYCLING Small excepted cells and batteries WASTE Applies to: Waste Lithium metal cells with a lithium metal content in excess of 1 g/cell Waste Lithium metal batteries with a lithium metal content in excess of 2 g/battery Waste Lithium ion cells with a Watt-hour rating in excess of 20 Wh/cell Waste Lithium ion batteries with a Watt-hour rating in excess of 100 Wh/battery UN No., Proper Shipping Name UN 3090, LITHIUM METAL BATTERIES or UN 3480, LITHIUM ION BATTERIES Class 9 Packing Group n/a Hazard Label • Labels must be in the form of a square set at an angle of 45° (diamond-shaped) with minimum dimensions of 100 mm by 100 mm; except for air transport mode, labels dimensions may be reduced in the case of packages of such dimensions that they can only bear smaller labels. • They must have a line 5 mm inside the edge and running parallel with it. Prerequisite • n/a Transport mode Road Marine Air Batteries being shipped for recycling or disposal are forbidden for transport by airccraft Packing instructions P909 P909 In strong outer packaging up to 30 kg gross mass meeting the general provisions of packagings. Packagings need not to be approved. Metal packagings shall be fitted with a non-conductive lining material (e.g. plastics) of adequate strength for the intended use. Additional requirements • Cells and batteries shall be designed or packed to prevent short circuits and the dangerous evolution of heat. • Protection against short circuits and the dangerous evolution of heat includes, but is not limited to: • individual protection of the battery terminals, • inner packaging to prevent contact between cells and batteries, • batteries with recessed terminals designed to protect against short circuits, or • the use of a non-conductive and non-combustible cushioning material to fill empty space between the cells or batteries in the packaging. • Cells and batteries shall be secured within the outer packaging to prevent excessive movement during carriage (e.g. by using a non-combustible and non-conductive cushioning material or through the use of a tightly closed plastic bag) Weight limit 30 kg Gross 30 kg Gross Exemptions (domestic voyage) Chapters: 1.15 up to 150 kg/vehicle 1.16 up to 150 kg/vehicle chapter 11.2 Passenger Carrying Road Vehicle 5 kg - Marking and Labelling of Packages UN 3090 or UN 3480 LITHIUM BATTERIES FOR DISPOSAL or LITHIUM BATTERIES FOR RECYCLING UN 3090, LITHIUM METAL BATTERIES or UN 3480, LITHIUM ION BATTERIES LITHIUM BATTERIES FOR DISPOSAL or LITHIUM BATTERIES FOR RECYCLING Overpack OVERPACK + same labels as above OVERPACK + same labels as above Documents Transport document Transport document 120 Copyright © www.batteriestransport.org
RkJQdWJsaXNoZXIy MjQwNg==