92 Copyright © www.batteriestransport.org 2.2.3_I LITHIUM ION CELLS PACKED WITH EQUIPMENT (including lithium alloy batteries) Fully regulated cells UN 3481 Applies to: Lithium ion cells packed with equipment, with a Watt-hour rating in excess of 20 Wh/cell UN No., Proper Shipping Name UN 3481, LITHIUM ION BATTERIES PACKED WITH EQUIPMENT Class 9 Packing Group Not assigned Hazard Label • Labels must be in the form of a square set at an angle of 45° (diamond-shaped) with minimum dimensions of 100 mm by 100 mm; except for air transport mode, labels may be reduced not less then 30mm by 30mm on small packages. • They must have a line 5 mm inside the edge and running parallel with it. Prerequisite • Cells must meet the General Requirements of § 1.3 in particular the test requirements Specific Requirements • Each cell incorporates a safety venting device or is designed to preclude a violent rupture under normal conditions of carriage; • Each cell is equipped with an effective means of preventing external short circuits • “Equipment” means apparatus requiring the lithium batteries with which it is packed for its operation. Transport mode Road Marine Air Passenger Aircraft Cargo Packing instructions P903 P903 PI 966 section I Lithium ion cells should be offered for transport at a State of Charge (SoC) ≤ 30 % of their rated capacity Cells must be protected against short circuit, including protection against contact with conductive materials within the same packaging that could lead to a short circuit. Two possible solution, lithium cells must: • be completely enclosed in inner packagings, then placed in a UN packaging of the type shown below that meets the Packing Group II performance standards, then placed with equipment in a strong, rigid outer packaging; or • be placed in inner packagings that completely enclose the cells, then placed with equipment in a packaging that meets the Packing Group II performance standards of a type shown below. The equipment must be secured against movement within the outer packaging. Packagings Drums (1A2, 1B2, 1N2, 1H2, 1D, 1G); Boxes (4A, 4B, 4N, 4C1, 4C2, 4D, 4F, 4G, 4H1, 4H2) Jerricans (3A2, 3B2, 3H2). Drums (1A2, 1B2, 1N2, 1H2, 1D, 1G); Boxes (4A, 4B, 4N, 4C1, 4C2, 4D, 4F, 4G, 4H2) Jerricans (3A2, 3B2, 3H2). Weight limit No limit No limit 5 kg Net 35 kg Net Exemptions (domestic voyage) Chapters: 1.15 up to 150 kg/vehicle 1.16 up to 500 kg/vehiclle chapter 11.2 - - Passenger Carrying Road Vehicle 5 kg - - - Marking and Labelling of Packages UN 3481 UN 3481 LITHIUM ION BATTERIES PACKED WITH EQUIPMENT UN 3481 LITHIUM ION BATTERIES PACKED WITH EQUIPMENT Full Name ad Address of the shipper and the consignee Net weight (kg) Minimum dimensions: 120 × 110 mm Overpack OVERPACK + same labels as above OVERPACK + same labels as above OVERPACK + same labels as above OVERPACK + same labels as above Documents Transport document Transport document Shipper’s Declaration
RkJQdWJsaXNoZXIy MjQwNg==